86-13641927045
No. B201, 2 Bldg, Allay 439, Jinglian Rd, Minhang District, Shanghai, China
Cummins Generator set series,gas generator set.
Engine of CUMMINS EG60 Natural Gas Generator Set | |
| Engine Model | CUMMINS 6BT |
| Type | 6 cylinders in line |
| Bore * Stroke (mm) | 102*120 |
| Displacement(L) | 5.9 |
| Compression ratio | 10.5:1 |
| Rated speed(rpm) | 1500-1800 |
| Inlet type | Exhaust Turbocharger(Air-Air Intercooler) |
| Cooling type | Cooling water tank |
| Fuel System | Low and high pressure |
| ESC Type | Special for U.S. GAC natural gas |
| Ignition sequence | 1-5-3-6-2-4 |
| The allowed maximum speed (Natural gas supply closed at this time) | 2160 rpm |
| The allowed maximum rotating speed (The ignition system shut down at this time) | 2160 rpm |
| Oil Capacity | 16.4 L |
| Cooling water capacity | 21.9 L |
| Maximum engine back pressure | 10.2 kpa |
| Gas consumption(m3-kw·h) | <0.3 |
| Rough oil consumption(g-kWh) | <1.5 |
| Radiator and oil cooler heat | 10.8 KW |
| Exhaust pipe heat radiation | 31 KW |
| Engine thermal radiation | 4.8 KW |
| Alternator thermal radiation | 3.6 KW |
| Cooling water temperature | 95 Deg C |
| Oil temperature | |
| Exhaust pipe heat energy (above 120 º C section) | 50 KW |
| Exhaust temperature (before vortex ) | 650±15 Deg C |
Alternator of CUMMINS EG60 Natural Gas Generator Set | |
| Alternator Model | Engga EG225M-60N |
| Excitation Method | Brushless Permanent Magnet |
| Winding pitch | 2-3 pitch |
| Number of poles | 4 |
| Bearing number | 1 |
| Stator Windings | 12 ends |
| Insulation Class | H class |
| Protection class | IP 21 or IP 23 |
| Load type | Continuous operation |
| AVR Model | WT-2 |
| Alignment | Fly wheel |
| Temperature Range | Less than 125 degrees Celsius |
| Overload Capacity- the percentage of rated power | 110% |
| Waveform distortion rate, no-load | <5% |
| Voltage Regulation Mode | AVR |
| Voltage Regulation Range | ±5% |
| Steady State Voltage Regulation | ±1% |
| No-load line voltage sine wave distortion | <2% |
| Telephone interference factor (TIF) | < 50 |
CUMMINS EG60 Natural Gas Generator Set | |
| Rated Output(KW) | 60 |
| Standby Output(KW) | 66 |
| Voltage(V) | 400 |
| Current(A) | 108 |
| Size(mm) | 1800*780*1420 |
| Approximate weight(KG) | 850 |
| Emission levels (Nox) | Euro II emission(mg-m³) |
| Naturally aspirated engine intake air temperature | None |
| Air temperature before entering the air to air intercooler | 82-87(Deg C) |
| Air temperature after entering the air to air intercooler | 35-42(Deg C) |
| Rated Power @ 0.8 power factor (w - pump s and w - o fan) | 60KW (continuous operation) |
| Total energy input (100% load) | 166(KW) |
| Electrical efficiency | 36.20% |
| Thermal efficiency | 87.90% |
| Control panel(Deepsea or others) | Synchronizing Control, Multilingual Mode Digital Control, Diagnostic Function, Direct Text Indicate of Faults, MOBUS Communication Protocol, Compatible Communication, Exchange Telecommunications, Wired Control Data Output, Automatic or manual start |
1) Deutz 413,513 series engine, Deutz 912.913 series engine, Deutz 1012,1013,1015 ,2012 series
2) Deutz D302 series ,TBD226 series,TBD 234 series, TBD 600 series, TBG 600 series
3) MTU 396TB series, 396SE Series 396TC/TB/TE series ,956 series
4) IVECO Cursor 9,NEF6, F1C engine
5) VM R425 DOHC,VM R428 DOHC,VM D704/D754 Series motor
6) Cummins M11,NT/NTA-855, KT/KTA/KTTA19,KT/KTA38, KTA/KTTA50, 4BT,6BT, C serials engine
7) Diesel engine spare parts
8) Nissan QD32T/TI engine
9) 4JA1,4BD1,6BD1
10) Lovol 1004 series and 1006 series
11) Pielstick PC2.2, 2.3, 2.4, 2.5, 2.6 PA6L-280,
12) Doosan P086TI and P086TI-1
13) GM6.5 engine
14) Cummins Generator set series 
